Herd Navigator and mastitis management

Transcription

1 Herd Navigator and mastitis management 1. What is mastitis? in some cases of E. coli mastitis the milk production in the affected Mastitis is the most common and costly disease in dairy herds. In quarter may go on total halt. As can be seen from figure 1, the milk many cases the farmer is only aware of the clinical cases observed composition will be altered. Fat and lactose levels are dropping, while during milking, although a large number of cows may be subclinically total protein levels change only slightly. Serum proteins are increasing infected with bacteria. and casein are decreasing leading to deteriorated cheese making Mastitis is an inflammation in the mammary gland primarily caused by bacterial infections. When bacteria are growing, they release metabolites and toxins that stimulate the defense mechanisms in the cow. The inflammation response leads to a migration of white blood quality. The milk concentrations of ions like sodium chloride are increasing resulting in an increased milk electrical conductivity. This can be used for early warning in automated milking, but the increase in electrical conductivity appears after the rise in NAGase and LDH. cells from the peripheral bloodstream into the udder. The Somatic Figure 1. Cell Count of the milk, which includes white blood cells, bacteria and somatic cells, increases from normally less than 100,000 cells/ml or less per udder quarter up to several million per ml. The increased cell count due to the inflammation is accompanied by a release of several enzymes, among these NAGase and Lactate Dehydrogenase (Sandholm et al., 1995, Ingvartsen 2001). The enzymes will be released from cells that have been damaged in the combat between bacteria and white blood cells. The more severe the inflammatory response, the higher activity of the enzymes. The pathological consequences of mastitis are tissue damage and alteration of secretory function. This leads to reduced milk yields and changes in milk composition. A correct estimation of the loss in milk yield is difficult, since non-infected udder quarters tend to compensate for the decrease in yield of the infected quarter, but the daily milk yield from the affected quarter can drop 9 kg, and a gradual increase after the mastitis case will last for up to 30 days (Rasmussen, 2006), Figure 1. Changes in milk components as related to increase in Somatic Cell Count, indicative of mastitis (Sandholm et al, 1995).

2 It has been reported that clinical mastitis rates are generally treated cases/100 cows per year. Subclinical infection levels are 5-35% of quarters infected by a major pathogen bacteria. The clinical mastitis is rather easy to detect for the farmer. The symptoms are clotting and discoloration of the milk, and the gland can become hard, red or swollen. In severe cases the cow has fever and loss of appetite. The subclinical mastitis can be more diffi cult to detect, since both the milk and udder can appear rather normal, while the Somatic Cell Count in the milk increases. The major issue associated with visual detection of mastitis is that in many cases the infl ammation has already been present for some time, resulting in poor treatment results, and the cow becoming a chronic mastitis case. Therefore, early detection of mastitis, before severe tissue damage has occurred is the best way to improve udder health. Early detection may also means that less antibiotics used for less days will save money to the farmer. With the advent of automatic milking udder health can be monitored by electrical conductivity, measured for each quarter. The major issue with monitoring electrical conductivity (and milk yield from each quarter) appears to be related to the present stage of development of the software to process the data, in the sense that the user is presented with a number of false alarms (Kamphuis et al., 2010). 2. Herd Navigator and detection of mastitis The Herd Navigator concept differs greatly from traditional mastitis detection, where the diagnosis is either based on clinical signs or in a robotic milking situation, changes in electrical conductivity and/or a rise in Somatic Cell Count (the DeLaval OCC). The milk component used to monitor udder health in Herd Navigator is the enzyme Lactate Dehydrogenase (LDH) which is released into the milk in the affected quarter during infl ammation. LDH is well correlated to the Somatic Cell Count (fi gure 3). Somatic Cells are typically white blood cells that arrive in the quarter to combat the bacterial infection and hence an indicator of the severity of the infection. Unfortunately the Somatic Cell Count can fl uctuate due to a number of cow factors (heats, heat stress, changes in feeding etc.), and therefore it is not always the best measure of an active infection, where LDH is increasing in an active infection and hence a better measure of mastitis. Figure 3. Recent economic analyses point to an average loss per case of clinical mastitis of approximately 143 (Bar et al, 2008). The costs were composed of 92 because of milk yield losses, 11 because of increased mortality, and 40 because of treatment-associated costs. Figure 2. Figure 3. The correlation between Somatic Cell Count (blue line) and LDH (red line) is very high, indicating that LDH is a good indicator of mastitis (Chagunda et al., 2005, based on 11,893 data records). Figure 2. Clinical mastitis can best be described as the iceberg. The purple cow is the one being detected as a mastitis cow, but underneath are several subclinically infected cows (the grey cows). Adapted after Nelson Philpot, Mastitis Management, 1978.

3 Herd Navigator will take milk samples for LDH-analyses at least once every day for 30 days from the fi rst entry to milking after calving, and hence build a so-called time series of analyses. This is the period where cows are at the highest risk of contracting mastitis. The biometric and biological model (fi gure 4) will assess the development in LDH-concentrations for each cow, and compute the risk of mastitis on a daily basis. From day 30 in lactation the Sampling Frequency Feedback (a mechanism in the mastitis model that tells the system when to take the next sample) will determine the days to next sample, based on the development in mastitis risk. Once the risk has reached the threshold level for mastitis, an alarm will appear on the user interface. As each cow will have her own reference value of LDH based on samples from the last week s samples, differences in baseline values refl ecting the cow s previous mastitis history will be accounted for. model, which is the ability to only issue mastitis alarms on true mastitis cases is 98 %. An example of the model s ability to detect mastitis can be seen from fi gure 5. The cow had a very high risk for mastitis at day 40, but clinical signs appeared as late as day 50, where the cow was treated. Figure 5. Figure 4 Sampling Frequency Feedback Measurement result from the analyzer Indicator Based Risk Biometric Model Additional Risk Factors Days in lactation - Milk yield - Other diseases Overall Risk = I.B Risk + Additional R.F. Output Risk Figure 4. Basic layout of the mastitis model. The output risk is formed by adding additional risk (e.g. stage of lactation, previous disease) to the indicator based risk (LDH measurements). The model will also issue a sampling frequency feedback to the system, depending on the development in the mastitis risk (Chagunda et al, 2005). Testing of the mastitis model in a Danish research herd showed a sensitivity of approximately 80 %. Some cases will go undetected, because they develop very rapidly. This is the case of some E. coli cases that may develop between two milkings. But most of the mastitis alarms will appear up to 4.5 days before clinical signs, leaving time to further investigate the case. The specifi city of the Figure 5. Results from the blinded testing of the mastitis model. The upper panel shows the development in LDH in a cow with mastitis. The red curve is the smoothed value of LDH. The lower panel shows the development in mastitis risk. The green dots indicate veterinary treatments for mastitis (after Chagunda et al., 2006). The mastitis model takes into account the degree of deviation in LDH from the baseline value, based on the cow s own development. This means that differences in LDH-concentration has the highest impact on mastitis risk when LDH concentrations are rising steeply from the baseline value

4 Herd Navigator used with DeLaval VMS systems can also deliver a quarter specific mastitis alarms. If differences in electric conductivity between quarters are of a certain magnitude, the probably affected quarter will also be part of the mastitis alarm. This will narrow down the bacteria culture to one quarter. In parlour milking, CMT- or DCC testing of quarters from a mastitis alarm cow can also guide the user to the quarter most likely at risk. In order to optimize mastitis management in a Herd Navigator herd we recommend a Standard Operating Procedure to be developed in cooperation with the herd veterinarian. A typical Standard Operating Procedure (SOP) for mastitis alarms may follow a pattern outlined in figure 6. Once the alarm is issued, a milk sample can be collected and analyzed. According to the culture result the cow will be treated or left untreated. Figure 6 Mastis risk > 70 % 1st alarm in present lactation? unless sick Perform culture No bacteria: Staphylococcus Aureus: Treat protocol A Staphylococcus spp. Treat protocol B Ecoli: Unless sick CNS Table 1. Number Herd Navigator alarm and treatment Herd Navigator alarm, no treatment No alarm, treated 2 2 Per cent Table 1. Herd Navigator mastitis alarms and mastitis treatments December 2009-March 2010 in a 277 cow herd with robotic milking (Bennedsgaard & Blom, 2011).. 3 Treatment of mastitis with Herd Navigator Treatment for mastitis can not be outlined here, as there are large differences in antibiotics available and practices used between territories. As we anticipate that treatment will be instituted earlier in a Herd Navigator herd, the treatment protocol may be limited to intramammary infusions of antibiotics, reducing antibiotic use and milk withdrawal time compared to e.g. intramuscular injections of antibiotics. This is currently being investigated in Danish test herds. Figure 6. Example of a Standard Operating Procedure (SOP) for mastitis management, used in Denmark. The SOP should be adapted the specific herd based on experience and the herd veterinarian s advice, and of course according to local legislation. It can be developed in the user interface. Table 1 shows results from a Danish test herd where on-farm culture was started in late Based on culture results and mastitis history, the majority of mastitis alarm cows were left untreated. Despite a decrease of 56 % in mastitis treatments the Bulk Milk Tank Somatic Cell Count was decreasing in 2010, compared to the same time period in 2009 (Bennedsgaard & Blom, 2011). The major cause of this change can be attributed to a better cure rate in treated cows, due to the early warning. The use of the system saves money, for treatments but also in terms of saved milk due to less treatments and a shorter withdrawal period for treated cows. In the case herd, the value of milk from cows not treated had a value of 7,400.

5 4 References Bennedsgaard, T.W. & J.Y.Blom Udder health and antibiotic use can be optimized by the combined use of Herd Navigator and on-farm culture. Proccedings, 50th Annual Conference, National Mastitis Council, Washington DC, January Bar, D, L.W. Tauer, G. Bennett, R.N. González, J.A. Hert, Y.H. Schukken, H.F. Schulte, F.L. Welcome & Y.T. Gröhn The Cost of Generic Clinical Mastitis in Dairy Cows as Estimated by Using Dynamic Programming. J. Dairy Sci., 91, Chagunda, M.G.G., Larsen, T., Bjerring, M., Ingvartsen, K.L., Changes in lactate dehydrogenase, N-acetyl-b-D-glucosaminase, and somatic cell count in relation to development of mastitis in dairy cows. Proc. of the 4th IDF International Mastitis Conference. Mastitis in dairy production. Current knowledge and future solutions (ed. H. Hogeveen). Wageningen Academic Publishers (ISBN ), Maastricht, the Netherlands, Chagunda, M.G.G., N.C. Friggens, M.D. Rasmussen and T. Larsen., A Model for Detection of Individual Cow Mastitis Based on an Indicator Measured in Milk. J. Dairy Sci., 89, Friggens, N.C, M.G.G Chagunda, M. Bjerring, C. Ridder, S. Højsgaard & T. Larsen Estimating Degree of Mastitis from Time-Series Measurements in Milk: A Test of a Model Based on Lactate Dehydrogenase Measurements. J. dairy Sci., 90, Ingvartsen, K.L A note on Lactate Dehydrogenase as a measure of udder health. Internal Report. Danish Institute of Agricultural Sciences, Research Centre Foulum, Foulum, Denmark. 12 pp. Kamphuis, C, H. Mollenhorst, A. Feelders, D. Pietersma, H. Hogeveen Decision-tree induction to detect clinical mastitis with automatic milking. Computers and Electronics in Agriculture. Vol 70, Rasmussen, M.D Changes in quarter yield and milking frequency - importance for handling mastitis in herds with AMS. Proceed. Cattle Consultancy Days, Nyborg, Denmark, Sandholm, M, T. Honkanen-Buzalski, L. Kartiinen & S. Pyöröla (ed.) The Bovine udder and mastitis. University of Helsinki, Faculty of Veterinary Medicine, Helsinki, Finland, 312 pp.