Elevated Egg Holding-Room Temperature of 74 F (23 C) Does Not Depress Hatchability or Chick Quality
|
|
- Lorin Welch
- 5 years ago
- Views:
Transcription
1 2003 Poultry Science Association, Inc. Elevated Egg Holding-Room Temperature of 74 F (23 C) Does Not Depress Hatchability or Chick Quality D. V. Bourassa,* R. J. Buhr,1 and J. L. Wilson* *Poultry Science Department, The University of Georgia, Athens, Georgia 30602; and Poultry Processing and Meat Quality Research Unit, Richard B. Russell Agricultural Research Center, USDA, ARS, P.O. Box 5677, Athens, Georgia Primary Audience: Breeder Managers, Hatching Egg Producers, Hatchery Managers, Researchers SUMMARY A series of experiments was conducted to determine the effect of holding broiler hatching eggs on the farm at 74 F (23 C) for 1 to 4 d prior to transport to the hatchery. After collection on each of 4 consecutive d, hatching eggs were distributed into two groups that were held at 66 or 74 F (19 to 23 C) and approximately 70% RH. On Day 5, all eggs were transported 10 miles to simulate transportation from the farm to the hatchery. Eggs were then placed into the hatchery egg cooler at 66 F (19 C), held overnight, and set the following morning after being allowed to warm at room temperature for 4 h. After 21 d of incubation, normal hatched chicks were counted, abnormal chicks were noted, and the hatch residue was opened and recorded. Additional eggs for each temperature group were set and opened after 48 h of incubation to determine if embryo somite count (an indication of embryonic development rate) was influenced by the egg holding temperatures. Somite counts after 48 h of incubation were the same for both temperature groups at 20.6 somites. Hatchability of fertile eggs differed between temperature groups by less than 0.1% [90.1% at 66 F (19 C) and 90.2% at 74 F (23 C)]. Elevating the farm holding-room temperature by 8 F (4 C) for broiler breeder eggs would conserve energy on the farm and reduce the potential for egg sweating during transport to the hatchery. Key words: broiler hatching egg, egg holding-room temperature, hatchability, somites 2003 J. Appl. Poult. Res. 12:1 6 DESCRIPTION OF PROBLEM To arrest further embryonic development and permit accumulation of large numbers of eggs for a synchronized hatch, broiler breeder hatching eggs are placed in coolers soon after collection. Farm egg coolers are typically set between 64 and 68 F (18 and 20 C), and eggs are held for 1 to 4 d prior to transport to the hatchery [1, 2]. Lower storage temperatures are recommended should the length of egg storage increase. For example, for eggs held less than 4 d, the egg room temperature should be 68 to 77 F (20 to 25 C). For eggs stored from 4 to 7 d, the temperature should be held at 61 to 63 F (16 to 17 C), and for eggs stored for more than 1 To whom correspondence should be addressed: jbuhr@saa.ars.usda.gov.
2 2 7 d, the temperature should be lowered to 50 to 54 F (10 to 12 C) [3]. Farm egg cooler temperatures between 64 and 68 F (18 and 20 C) are below the temperature that will arrest further embryonic development, known as physiological zero [commonly accepted to be 68 to 70 F (20 to 21 C)] and will also accommodate additions of warm eggs to the egg-holding cooler several times daily [4, 5]. A slightly higher temperature of 76 F has been reported for physiological zero when determined as the temperature that hatching eggs must be warmed above to reinitiate development [6]. Hatching eggs are ordinarily transported to the hatchery twice weekly. Increasing the egg holding temperature by a few degrees for 3 to 4 d may not have detrimental effects on hatchability and chick quality while decreasing the potential for egg sweating as well as lowering energy consumption on the farm. Egg sweating occurs when a cool egg is moved into a warm room, because moisture from the air will condense onto the cooler eggshell surface. Trucks that transport eggs from the farm to the hatchery may not be refrigerated. Environmental temperature and relative humidity could then be a factor as to whether or not the eggs sweat. If eggs are held at warmer temperatures, then sweating would be less likely to occur during transport. If an egg is moved from an egg cooler set at 68 F (20 C) and placed into a transport vehicle at 74 F (23 C), the egg will sweat if the RH is 76% or higher. On the other hand, if an egg is held at 74 F (23 C) and transported at 74 F (23 C) then sweating is not likely to occur unless the RH is 100%. It has been shown that recontamination of hatching eggs occurs during transport from the farm to the hatchery, and egg sweating may play an important role [7]. Sweating may be detrimental because as condensation collects on the egg, dust and bacteria may accumulate more easily, therefore giving rise to the heightened possibility of contamination [8]. Bacterial contamination of the albumen and yolk was demonstrated when eggs were permitted to sweat for 1, 2, or 5 h during 12 d of storage, whereas the contents of control unsweated eggs remained free from contamination [9]. Sweating may also be a potential source of cross-contamination of eggs from different farms during transport or within the hatchery. JAPR: Research Report Finally, a warmer temperature for egg holding at the breeder farm may have a beneficial effect on hatchability. After oviposition the blastoderm has initiated differentiation into the three embryonic germinal layers: ectoderm, mesoderm, and endoderm. An embryo that has developed these three layers is described as entering the gastrulation stage of development. Embryos that are in an early gastrulation stage do not hatch as well as those that are in more advanced stages of gastrulation [10]. If these early gastrulation embryos can continue to develop by holding the eggs at a higher temperature on the farm for 3 or 4 d, hatchability of these eggs may be improved. MATERIALS AND METHODS Hatching eggs were collected from a university broiler breeder flock at 29, 37, 43, and 47 wk of age (Trials 1 through 4, respectively) once per day in the afternoon. Hens were housed in an environmental-type building partitioned into floor pens that were two-thirds elevated slats and one-third litter. Hens were provided a typical corn-soybean meal breeder layer diet in mash form (2,860 kcal ME/kg and 16% CP). Each day, eggs from each egg flat that were cracked, dirty, or misshapen were discarded, and the remaining eggs were evenly distributed into four 88-egg racks and labeled duplicate racks A and B(n= 88 eggs/rack). Two racks (one A and one B) were held in a cooler at 74 ± 2 F (23 ± 1 C) for the experimental groups. The other two racks were held at 66 ± 2 F (19 ± 1 C) and served as the control groups. To monitor air temperature in both egg coolers, data loggers were used to record temperature and RH every minute, directly above the eggs [11]. We used a total of 5,632 broiler breeder eggs (704/treatment per trial) in the four trials of this experiment. For each trial, eggs were collected for 4 consecutive d between 1400 and 1600 h. On Day 5, the eggs were loaded into an unrefrigerated vehicle and driven 10 miles to simulate transportation from the farm to the hatchery. All eggs were then held at 66 F (19 C) overnight, and on Day 6 they were allowed to warm at room temperature for 4 h and then set in an incubator [12] operating at 99.5 F (23 C) and 55% RH, with turning every hour. One rack from each of the two treatment groups was placed on each
3 BOURASSA ET AL.: EGG HOLDING TEMPERATURE AND HATCH 3 TABLE 1. Infertility and hatchability of eggs set, hatchability of fertile eggs, and abnormalities of embryos and chicks from eggs held at 66 and 74 F (19 and 23 C) for 1 to 4 d prior to setting A Infertility of Hatch of eggs Hatch of Embryo & chick Holding eggs set set fertile eggs abnormalities C temperature Trials B (%) (%) (%) (%) 66 F (19 C) 1, 2, 3, , 3, F (23 C) 1, 2, 3, , 3, Probability P 1, 2, 3, , 3, A n = 704 eggs set per trial for each egg holding temperatures. B In Trial 2 a lack of turning from Days 11 to 14 of incubation resulted in decreased hatchability. C Percentage of late dead embryos and cull chicks. level of the setter buggy, and treatment groups were alternated from the front and back of the incubator. At 11 d of incubation, eggs were candled, and all nonviable eggs were removed and broken out to determine infertile, positive development, and early dead embryos. At transfer (18 d), the eggs were candled again to determine middle dead, and viable eggs were moved into one hatcher. When the chicks hatched at 21 d, normal chicks were counted, abnormal chicks were noted, and the entire remainder was broken out and recorded. Typical abnormalities entailed anterior and posterior duplications, brain hernias, spinabifida, or malpositions. Recorded abnormalities for hatched chicks were poor umbilical closure, weak legs, and head anomalies. FIGURE 1. Hatchability of eggs set and hatchability of fertile eggs with increasing flock age. Somite Counts In addition to the previous stated procedures, 120 extra eggs were collected and held for both temperature groups following the same procedures described. After 48 h of incubation, these eggs were placed into a refrigerator at 35 F(2 C) to rapidly arrest development and then were opened for somite count determination over the following 3 d. Somites were counted to determine whether eggs held at the higher temperature showed a corresponding accelerated development compared to the control. Each egg was opened into a bowl half filled with water, and the embryo was stained with neutral red [13]. The vitelline membrane over the embryo was removed, and additional stain was applied. Individual somites from the auditory pit to the last complete somite were counted under a dissection microscope and recorded. Forty-eight hours of incubation was chosen because there are adequate number of somites to count at this age. Statistical Analysis Hatchability of eggs set, hatchability of fertile eggs, and somite counts were analyzed with the general linear model procedure of SAS software [14], and the percentage of fertile eggs and percentage of abnormalities for embryos and chicks were analyzed by the chi-squared test procedure. The experimental unit was a rack of 88 eggs, with two racks per treatment per day. Sources of variation in the model included the following main effects: egg holding temperature
4 4 66 or 74 F (19 or 23 C), day of egg collection (1 through 4), trials (1 through 4), and duplicate egg racks (A or B). There was no significance attributed to the day of egg collection or duplicate egg racks (A and B) within or between trials; therefore the data were combined and reanalyzed by holding temperature treatment and trial. There was a significant effect in Trial 2 on hatchability due to the accidental absence of turning during incubation on Days 11 through 14 (turner remained off following candling). Therefore, the results were analyzed and are presented including and excluding Trial 2. For all analyses, significance was determined at P < RESULTS AND DISCUSSION The results of these four trials demonstrated that broiler hatching eggs can be safely held at 74 F (19 C) on the farm (8 For4 C higher than is commonly recommended) for 1 to 4 d prior to transport to the hatchery and maintain high hatchability and chick quality. There were no significant differences in hatchability in the four trials for eggs collected on Days 1 to 4, and therefore the data have been presented combined for day of egg collection for each trial. Hatchabilities of fertile eggs were 92.9, 75.3, 87.1, and 90.7% for Trials 1 to 4, respectively (Figure 1). A lack of turning in the setter from Days 11 to 14 of incubation in Trail 2 most likely resulted in the corresponding reduction in hatchability [15]. However, there were no significant differences in hatchability between the two egg holding temperature groups. Figure 1 shows the hatchability of fertile eggs as the flock age increased over the four trials. For each trial, the values for the control and treatment groups overlapped and responded in the same pattern over time. The results are presented in Table 1, with and without Trial 2, because of the depressed hatchability in this trial compared to the other three trials. With Trial 2 included, the hatchability of fertile eggs was 86.4% for eggs held at 66 F (19 C) compared to 86.5% for eggs held at 74 F (23 C). The average hatchability of fertile eggs with Trial 2 excluded was 90.1% for eggs held at 66 F (19 C) compared to 90.2% for eggs held at 74 F (23 C). The percentages of infertile eggs set did not differ among egg holding temperature groups JAPR: Research Report FIGURE 2. Percentage infertile of eggs set and abnormalities of embryos and hatched chicks with increasing flock age. and were 1.6, 6.5, 8.9, and 14.1% for Trials 1 through 4, respectively (Figure 2). This trend of the breeder flock from 29 to 47 wk of age could be attributed to the nature of the study for which the eggs were collected (rooster mating behavior). The addition of spike roosters had not occurred. It is important to note that detected infertility did not differ between the two egg holding temperature groups (Figure 2), therefore large numbers of very early dead embryos or blastoderms that failed to reinitiate development were not incorrectly classified as infertile. This distinction is important when reviewing the impact of egg holding temperature and storage length from the literature. Typically as egg storage length increases, there are associated increases in apparent infertility [16]. The increased infertility from 29 to 47 wk of age in this study resulted in corresponding reductions in hatchability of eggs set as the four trials progressed, but there were no differences between egg holding temperature groups (Figure 1). Hatchabilities of eggs set decreased as flock age increased for Trials 1 to 4 from 91.4, 70.4, 79.0, and 77.5% (Figure 1). The incidence of embryonic and chick abnormalities also did not significantly differ between the two egg holding treatment groups or among the four trials (Figure 2). Combining embryo and chick abnormalities and when expressed as a percentage of total number of dead embryos and cull chicks, there were numerically fewer abnormalities from the eggs held at 74 F (23 C; 20.3%) than those held at 66 F (19 C;
5 BOURASSA ET AL.: EGG HOLDING TEMPERATURE AND HATCH %; Table 1). Therefore, the increased holding temperature of 8 F (4 C) did not induce elevated levels of embryo or chick abnormalities. Somite counts after 48 h of incubation were also similar for the two egg holding temperature groups at 20.6 somites per egg. The number of somites after 48 h of incubation for eggs held at 66 F (19 C) was 20.3 somites and for eggs held at 74 F (23 C) was 20.9 somites. A maximum somite count of 25 and a minimum of 16 were counted for the 60 embryos in each egg holding temperature group. Elevation of egg holding temperature by 8 F for 1 to 4 d was not sufficient to result in significant acceleration of somite formation after 48 h of incubation. However, when eggs from Single Comb White Leghorn hens were left in the nest for 6 to 7 h and then stored at 56.8 F (13.8 C) for 4 d, preincubation embryonic development was advanced by 1.22 Eyal-Giladi and Kochav stages [17]. Similarly, when the eggs from broiler breeder hens were allowed to remain in the nest for 6.5 h compared to those collected after 1.5 h, advance- ment in embryonic development of 1.29 Eyal- Giladi and Kochav stages was reported [18]. This postlay development was attributed to the elevated environmental temperatures [from 80 to 86 F (27 to 30 C)] or possible partial incubation of the eggs by the hens during the 6.5-h period. The pre-egg collection advancement in development from Single Comb White Leghorns, however, was not sufficient to alter hatchability (95.9%) [17]. In the present report, embryos were not evaluated prior to setting, and, therefore, it is not known if after 1 to 4 d of holding eggs at 74 F (23 C) there would have been a detectable advancement in development. Future research will attempt to quantify the actual energy savings that result by elevating the breeder farm egg cooler temperature 8 F to 74 F (23 C). The role that egg sweating plays in eggshell surface contamination during transport from the farm to the hatchery will also be evaluated. Variability in breeders strains, age of breeders, and the season of the year may all impact the quantitative benefits related to hatchability in response to elevated holding temperatures. CONCLUSIONS AND APPLICATIONS 1. Holding broiler hatching eggs in the farm egg cooler for 1 to 4 d at 74 F (23 C) vs. 66 F (19 C) did not alter hatchability or incidence of embryo or chick abnormalities. 2. It may be possible to save refrigeration energy costs by increasing farm egg cooler temperatures by 8 F (4 C) and still maintain high hatchability. 3. Holding broiler hatching eggs on the farm for 1 to 4dat74 F (23 C) vs. 66 F (19 C) did not advance embryo somite counts after 48 h of incubation or apparently alter incubation length. 4. Increasing on-farm broiler hatching egg holding temperature to 74 F (23 C) may prevent egg sweating during transport and thereby decrease the incidence of surface bacterial contamination. REFERENCES AND NOTES 1. Peterson Farms 2. Cobb 500 Breeder Management Guide. Cobb-Vantress, Inc., Meijerhof, R Pre-incubation holding of hatching eggs. World s Poult. Sci. J. 48: Edwards, C. L The physiological zero and the index of development for the egg of the domestic fowl. Am. J. Physiol. 6: Proudfoot, R. G., and H. W. Hulan Care of hatching eggs. Publication 1573/E, Agriculture Canada, Ottawa, ON, Canada. 6. Funk, E. M., and H. V. Biellier The minimum temperature for embryonic development in the domestic fowl (Gallus domesticus). Poult. Sci. 23: Berrang, M. E., J. F. Frank, R. J. Buhr, J. S. Bailey, N. A. Cox, and J. M. Mauldin Microbiology of sanitized broiler hatching eggs through the egg production period. J. Appl. Poult. Res. 6: Forsythe, R. H., J. C. Ayres, and J. L. Radlo Factors affecting the microbiological population of shell eggs. Food Technol. 7: Fromm, D., and P. H. Margolf The influence of sweating and washing on weight loss, bacteria contamination and interior physical quality of 12-day old shell eggs. Poult. Sci. 37: Hays, F. A., and C. Nicolaides Variability in development of fresh-laid hen eggs. Poult. Sci. 13: Sensitech Hatware Ryan HAT Version 1.9. Sensitech, Redmond, WA.
6 6 JAPR: Research Report 12. NatureForm, NMC 2000, Jacksonville, FL. 13. Neutral Red. For 100 ml of solution, mix 0.85 g NaCl, g KCl, g CaCl, and 100 ml distilled water. Add g Neutral Red (Sigma # N6634). Mix. Jackie Pisenti, University of California-Davis, jmpisenti@ucdavis.edu. 14. SAS Institute SAS/STAT Guide for Personal Computers. Version 7 Edition. SAS Institute Inc., Cary, NC. 15. Wilson, H. R Physiological requirements of the developing embryo: Temperature and turning. Pages in Avian Incubation. S. G. Tullett, ed. Butterworth-Heinemann, Northants, England. 16. Landauer, W The hatchability of chicken eggs as influenced by environment and heredity. Monograph 1 (rev.). Storrs Agricultural Experiment Station, University of Connecticut, Storrs, CT. 17. Fasenko, G. M., F. E. Robinson, J. G. Armstrong, J. S. Church, R. T. Hardin, and J. N. Petitte Variability in preincubation embryo development in domestic fowl. 1. Effects of nest holding time and method of egg storage. Poult. Sci. 70: Fasenko, G. M., J. L. Wilson, F. E. Robinson, and R. T. Hardin Effects of length of egg nest holding time and high environmental temperatures on prestorage embryonic development, survival, and hatchability of broiler breeders. J. Appl. Poult. Res. 8:
Hatchability and Early Chick Growth Potential of Broiler Breeder Eggs with Hairline Cracks
2004 Poultry Science Association, Inc. Hatchability and Early Chick Growth Potential of Broiler Breeder Eggs with Hairline Cracks D. M. Barnett, B. L. Kumpula, R. L. Petryk, N. A. Robinson, R. A. Renema,
More informationFFA Poultry Career Development Event 2000 Poultry Judging Contest Arkansas State FFA Judging Contest
FFA Poultry Career Development Event 2000 Poultry Judging Contest Arkansas State FFA Judging Contest Contestant Name: Contestant ID: 1. The per capita egg consumption is: A. 100 eggs per year B. 234 eggs
More informationEMBRYO DIAGNOSIS AN IMPORTANT TOOL TO HELP THE HATCHERY MANAGER
Issue No.14 / September 2007 EMBRYO DIAGNOSIS AN IMPORTANT TOOL TO HELP THE HATCHERY MANAGER By Avian Business Unit CEVA Santé Animale Libourne, France INTRODUCTION Chick quality is the first criterion
More informationSection 6. Embryonic Development and Hatchery Management Notes
Section 6 Embryonic Development and Hatchery Management Notes Slide 2 A well run hatchery is critical for any integrated poultry company whether it be a primary breeder company or a commercial meat company.
More informationInternal Egg Temperature in Response to Preincubation Warming in Broiler Breeder and Turkey Eggs
2006 Poultry Science Association, Inc. Internal Egg Temperature in Response to Preincubation Warming in Broiler Breeder and Turkey Eggs R. A. Renema, J. J. R. Feddes, 1 K. L. Schmid, M. A. Ford, and A.
More informationCare of the egg: from nest to farm store9
Care of the egg: from nest to farm store9 By Gerd de Lange, senior poultry specialist, Pas Reform Academy A healthy, well managed breeder flock, receiving a balanced feed ration, will produce good quality
More informationOn-Farm Factors Affecting the Hatchability of Broiler Eggs in Parent. Breeder Operations
On-Farm Factors Affecting the Hatchability of Broiler Eggs in Parent Breeder Operations Jessica B. Hill Virginia Polytechnic Institute and State University Masters in Agriculture and Life Sciences Adviser:
More informationPRODUCTION, MODELING, AND EDUCATION
PRODUCTION, MODELING, AND EDUCATION Influence of Egg Shell Embryonic Incubation Temperature and Broiler Breeder Flock Age on Posthatch Growth Performance and Carcass Characteristics R. Hulet,* 1 G. Gladys,
More informationIT HAS been well established that
The Effect of Different Holding Temperatures on the Hatchability of Hens' Eggs M. W. OLSEN AND S. K. HAYNES Agricultural Research Center, Beltsville, Maryland IT HAS been well established that storage
More informationINCUBATION AND VITAL MORPHOLOGICAL TRAITS IN EGGS FROM AGE-RELATED TURKEYS
Trakia Journal of Sciences, Vol. 7, No. 1, pp 63-67, 2009 Copyright 2009 Trakia University Available online at: http://www.uni-sz.bg ISSN 1313-7050 (print) ISSN 1313-3551 (online) Original Contribution
More informationIncubation Temperature for Ostrich (Struthio camelus) Eggs
Incubation Temperature for Ostrich (Struthio camelus) Eggs S. M. Hassan,*, A. A. Siam, M. E. Mady, and A. L. Cartwright*,1 *Poultry Science Department, Texas A&M University, College Station, Texas 77843-2472;
More informationThe critical importance of incubation temperature
The critical importance of incubation temperature Nick A. French AVIAN BIOLOGY RESEARCH 2 (1/2), 2009 55 59 Aviagen Turkeys Ltd, Chowley Five, Chowley Oak Business Park, Tattenhall, Cheshire, CH3 9GA,
More informationLow Temperature Effects on Embryonic Development and Hatch Time 1
Low Temperature Effects on Embryonic Development and Hatch Time M. E. SUAREZ/ H. R. WILSON,^ B. N. MCPHERSON,* F. B. MATHER,+ and C. J. WILCOXt *Programa de Ganaderia, Colegio de Postgraduados, Montecillo,
More informationHATCHABILITY THE TIMING OF MAJOR EMBRYONIC DEVELOPMENTS
HATCHABILITY Understanding timely embryonic developments, as well as analysing hatch residue, are a useful hatchery management tools. They will provide valuable information in isolating problems in both
More informationChick quality: hatchery impact on broiler performance. Scott Martin LLC - USA
Chick quality: hatchery impact on broiler performance Scott Martin LLC - USA Chick Quality Hatchery Impact on Performance Scott Martin SCOTT MARTIN, LLC. Field Performance FCR Advantage Advantage of 2
More informationFEEDING CHINESE RINGNECK PHEASANTS FOR EFFICIENT REPRODUCTION. Summary *
FEEDING CHINESE RINGNECK PHEASANTS FOR EFFICIENT REPRODUCTION Robert E. Moreng, William K. Pfaff and Eldon W. Kienholz Summary * Two trials were conducted each using 240 Chinese Ringneck pheasant breeder
More informationChick Quality breeder and hatchery influences. Daniel B Pearson Veterinary Health Director Aviagen UK Ltd
Chick Quality breeder and hatchery influences Daniel B Pearson Veterinary Health Director Aviagen UK Ltd Outline Definition of chick quality Nutrition Health Inputs Egg Hatchery Chick handling, storage
More informationInfluence of Slat Material on Hatching Egg Sanitation and Slat Disinfection
Journal of Applied Poultry Research Volume 12, Spring 2003 Number 1 2003 Poultry Science Association, Inc. Influence of Slat Material on Hatching Egg Sanitation and Slat Disinfection J. E. Sander,*,1 J.
More informationFFA Poultry Career Development Event 2004 Poultry Judging District Contests
FFA Poultry Career Development Event 2004 Poultry Judging District Contests 1. In a market broiler house, heaters should be turned on to preheat the house hours before the chicks arrival. A. 5-10 hours
More informationKey facts for maximum broiler performance. Changing broiler requires a change of approach
Key facts for maximum broiler performance Changing broiler requires a change of approach Good chick quality = UNIFORMITY everywhere in the supply chain Performance 1. Professional breeder house / management
More informationof Nebraska - Lincoln
University of Nebraska - Lincoln DigitalCommons@University of Nebraska - Lincoln Publications from USDA-ARS / UNL Faculty U.S. Department of Agriculture: Agricultural Research Service, Lincoln, Nebraska
More informationINFO SHEET. Cull Eggs: What To Expect And How To Reduce The Incidence.
INFO SHEET Cull Eggs: What To Expect And How To Reduce The Incidence info.hybrid@hendrix-genetics.com www.hybridturkeys.com Introduction Over the years, several Hybrid customers have inquired about the
More informationDr. Kenneth E. Anderson Poultry Science Department North Carolina State University Box 7608 Raleigh, NC
33 rd NORTH CAROLINA LAYER PERFORMANCE AND MANAGEMENT TEST HATCH AND SEROLOGY SUMMARY Vol. 33, No. 1 October 1998 The North Carolina Layer Performance and Management Test is conducted under the auspices
More informationEffect of Storage and Layer Age on Quality of Eggs From Two Lines of Hens 1
Effect of Storage and Layer Age on Quality of Eggs From Two Lines of Hens 1 F. G. Silversides*,2 and T. A. Scott *Crops and Livestock Research Centre, Charlottetown, Prince Edward Island, Canada C1A 7M8
More informationAviagenBrief. Best Practice Management in the Absence of Antibiotics at the Hatchery. October Aviagen Veterinary Team.
AviagenBrief October 2017 Best Practice Management in the Absence of Antibiotics at the Hatchery Aviagen Veterinary Team Introduction In light of increased antibiotic resistance, and as consumer pressure
More informationThe Effects of Suboptimal Eggshell Temperature During Incubation on Broiler Chick Quality, Live Performance, and Further Processing Yield
The Effects of Suboptimal Eggshell Temperature During Incubation on Broiler Chick Quality, Live Performance, and Further Processing Yield N. S. Joseph,* A. Lourens, and E. T. Moran Jr.* 1 *Department of
More informationFollowing on from the Aviagen
1 Successful incubation Following on from the Aviagen articles in International Poultry Production during 2006 we will be producing a series of articles with an incubation and hatchery theme for International
More informationEFFECT OF MULTI-STAGE INCUBATOR TYPES ON HATCHABILITY AND CHICK QUALITY OF BROILER CHICKEN
Wayamba Journal of Animal Science ISSN: 2012-578X; P1737 - P1742, 2018 First Submitted October 02, 2018; Number 1533274662 EFFECT OF MULTI-STAGE INCUBATOR TYPES ON HATCHABILITY AND CHICK QUALITY OF BROILER
More informationMETABOLISM AND NUTRITION. The Utilization of Brewers' Dried Grains in the Diets of Chinese Ringneck Pheasant-Breeder Hens 1-2
METABOLSM AND NUTRTON The Utilization of Brewers' Dried Grains in the Diets of Chinese Ringneck Pheasant-Breeder Hens - W. K. PFAFF, 3 R. E. MORENG, and E. W. KffiNHOLZ Department of Animal Sciences, Colorado
More informationEFFECTS OF BODY WEIGHT UNIFORMITY AND PRE-PEAK FEEDING PROGRAMS ON BROILER BREEDER HEN PERFORMANCE
2001 Poultry Science Association, Inc. EFFECTS OF BODY WEIGHT UNIFORMITY AND PRE-PEAK FEEDING PROGRAMS ON BROILER BREEDER HEN PERFORMANCE B. P. HUDSON, R. J. LIEN 1, and J. B. HESS Department of Poultry
More informationRelationships of incubational hatching egg characteristics to posthatch body weight and processing yield in Ross Ross 708 broilers 1,2
2014 Poultry Science Association, Inc. Relationships of incubational hatching egg characteristics to posthatch body weight and processing yield in Ross Ross 708 broilers 1,2 E. D. Peebles,* 3 R. Pulikanti,*
More informationCHICKENS 101 BIOLOGY (ANATOMY, BREEDS, DEVELOPMENT, & REPRODUCTION)
CHICKENS 101 BIOLOGY (ANATOMY, BREEDS, DEVELOPMENT, & REPRODUCTION) THE BASICS: TERMS 1 Chicken Anatomy 3 THE BASICS: TERMS 1 Chicken Wing & Feather Anatomy 4 THE BASICS - TERMS 1 Chick a new hatch or
More informationOptimum broiler development. A practical guide to ensure correct early broiler performance
Optimum broiler development A practical guide to ensure correct early broiler performance 1.1. Why focus on incubation? Today s meat yield birds can produce higher embryonic temperatures and the risk of
More informationThe Importance of Timely Removal from the Incubator of Hatched Poults from Three Commercial Strains 1
The Importance of ly Removal from the Incubator of Hatched Poults from Three Commercial s 1 V. L. CHRISTENSEN and W. E. DONALDSON Department of Poultry Science, North Carolina State University, Raleigh,
More information2018 MN FFA Poultry CDE Exam
2018 MN FFA Poultry CDE Exam Do not write on the exam. Mark the most correct answer on the exam section of your scantron. 1. The production goals of the table egg industry are to produce how many eggs
More informationEDUCATION AND PRODUCTION. Layer Performance of Four Strains of Leghorn Pullets Subjected to Various Rearing Programs
EDUCATION AND PRODUCTION Layer Performance of Four Strains of Leghorn Pullets Subjected to Various Rearing Programs S. LEESON, L. CASTON, and J. D. SUMMERS Department of Animal and Poultry Science, University
More informationFFA Poultry Career Development Event 2004 NEO Aggie Day. 1. With regard to egg storage, which of the following statements is FALSE?
FFA Poultry Career Development Event 2004 NEO Aggie Day 1. With regard to egg storage, which of the following statements is FALSE? A. The longer the egg storage time, the higher the egg storage temperature
More informationHatching Quality Chicks
Hatching Quality Chicks Incubating and hatching domestic fowl eggs is popular among people who have a small flock for eggs and meat and hobbyists with ornamental and fancy birds. These people benefit largely
More informationSANITARY MANAGEMENT OF THE HATCHING EGGS
Issue No.11 / March 2007 SANITARY MANAGEMENT OF THE HATCHING EGGS By Avian Business Unit - CEVA Santé Animale Libourne - FRANCE INTRODUCTION Unquestionably, the sanitary quality of the hatching eggs will
More informationRelationship between hatchling length and weight on later productive performance in broilers
doi:10.1017/s0043933908000226 Relationship between hatchling length and weight on later productive performance in broilers R. MOLENAAR 1 *, I.A.M. REIJRINK 1, R. MEIJERHOF 1 and H. VAN DEN BRAND 2 1 HatchTech
More informationLAYING BEHAVIOUR OF EGG AND MEAT TYPE CHICKEN AS INFLUENCED BY NEST TIER
Wayamba Journal of Animal Science ISSN: 2012-578X; P839-P844, 2014 First Submitted December 01, 2013; Number 1385910056 LAYING BEHAVIOUR OF EGG AND MEAT TYPE CHICKEN AS INFLUENCED BY NEST TIER B. Roy 1,
More informationReducing Airborne Pathogens, Dust and Salmonella Transmission in Experimental Hatching Cabinets Using an Electrostatic Space Charge System
Reducing Airborne Pathogens, Dust and Salmonella Transmission in Experimental Hatching Cabinets Using an Electrostatic Space Charge System B. W. Mitchell,*,1 R. J. Buhr, M. E. Berrang, J. S. Bailey, and
More informationThe Hatch Window. Publication of Cobb-Vantress, Inc. ONE
Publication of Cobb-Vantress, Inc. ONE - 2008 The hatching of strong, viable birds is a key factor in increased broiler performance. To increase the probability of strong birds, good hatchery management
More informationEDUCATION AND PRODUCTION. The Relationships Among Measures of Egg Albumen Height, ph, and Whipping Volume 1
EDUCATION AND PRODUCTION The Relationships Among Measures of Egg Albumen Height, ph, and Whipping Volume 1 F. G. Silversides*,,2 and K. Budgell *Crops and Livestock Research Centre, Charlottetown, Prince
More informationPerformance of Broiler Breeders as Affected by Body Weight During the Breeding Season 1
Performance of Broiler Breeders as Affected by Body Weight During the Breeding Season 1 H. R. WILSON and R. H. HARMS Department of Poultry Science, University of Florida, Gainesville, Florida 32611 (Received
More informationEgg Marketing in National Supermarkets: Products, Packaging, and Prices Part 3
Egg Marketing in National Supermarkets: Products, Packaging, and Prices Part 3 K. W. Koelkebeck,*,1 D. D. Bell, J. B. Carey, K. E. Anderson, and M. J. Darre *Department of Animal Sciences, University of
More informationHow Does Photostimulation Age Alter the Interaction Between Body Size and a Bonus Feeding Program During Sexual Maturation?
16 How Does Photostimulation Age Alter the Interaction Between Body Size and a Bonus Feeding Program During Sexual Maturation? R A Renema*, F E Robinson*, and J A Proudman** *Alberta Poultry Research Centre,
More informationCritical Points to Consider at the Incubation Process Guaranteeing Quality Chicks. Eddy Van Lierde Aviagen Hatchery Development & Support
Critical Points to Consider at the Incubation Process Guaranteeing Quality Chicks. Eddy Van Lierde Aviagen Hatchery Development & Support Essentials of Incubation For a fertile egg to produce a chick,
More informationROSS TECH 07/46 Managing the Ross 708 Parent Stock Female
ECH ROSS TECH 07/46 Managing the Ross 708 Parent Stock Female 1 Aviagen provides customers with detailed Product Performance Specifications, Management Manuals and Nutrition Specifications as the basis
More informationThe Effect of Oviposition Time on Egg Quality Parameters in Brown Leghorn, Oravka and Brahma Hens
The Effect of Oviposition Time on Egg Quality Parameters in Brown Leghorn, Oravka and Brahma Hens Cyril Hrnčár* 1, Monika Hässlerová 1, Jozef Bujko 2 1 Department of Poultry Science and Small Animal Husbandry
More informationChecking Out Chickens
Ag in 10 Minutes a Day! Checking Out Chickens Poultry is a group of domestic fowl that includes chickens, turkey, ducks, ostriches, emus, and geese. These animals are all eaten for their meat. The fowl
More informationThe Effect of Angle of Turning Eggs During Incubation on Hatchability
The Effect of Angle of Turning Eggs During Incubation on Hatchability E. M. FUNK AND JAMES FORWARD Figure 1. Insid e view of incubator used in egg turning experiments. Left to ri gh t the col umns of trays
More informationSO YOU'RE GOING TO HAVE A BABY... CHICK!! Tips for Teachers Embarking on the Embryology Experience
SO YOU'RE GOING TO HAVE A BABY... CHICK!! Tips for Teachers Embarking on the Embryology Experience by Walter Reeves The Georgia Gardener (tm) INTRODUCTION Incubating eggs is a marvelous learning experience
More informationChasing Chickens: 40 Years of Pecking and Scratching. Nelson A. Cox ARS-PMSRU Russell Research Center, Athens GA 30607
Chasing Chickens: 40 Years of Pecking and Scratching Nelson A. Cox USDA-ARS ARS-PMSRU Russell Research Center, Athens GA 30607 Education (LSU) B. S. (1966) Bacteriology M. S. (1968) Food Science (Microbiology
More information1^1. Agriculture Canada. Publication 1573/E. Care of hatching. before incubation. + Canada. *. Agriculture _. ft/,? t& jf.
1^1 Agriculture Canada Publication 1573/E û9 Care of hatching before incubation + Canada *. Agriculture _ ft/,? 2 1990 3t& jf Canada Agriculture Canada Publication 1573 K available from Communications
More informationEffect of EM on Growth, Egg Production and Waste Characteristics of Japanese Quail Abstract Introduction Experimental Procedures
Effect of EM on Growth, Egg Production and Waste Characteristics of Japanese Quail S. Chantsavang, P. Piafupoa and O. Triwutanon Department of Animal Science, Kasetsart University, Bangkok, Thailand Abstract
More informationIndustry Vision and Mission for Quality..3. Background and Executive Summary. 4-5
Version 3.0 1 2 Industry Vision and Mission for Quality..3 Background and Executive Summary. 4-5 Industry Standards for Broiler Chick Quality: 1. Laying and Handling of Eggs 6 2. Incubation and Hatching
More informationEffect of location of eggs in the incubator on hatchability of eggs from Bronze turkey breeders of different ages
214 Effect of location of eggs in the incubator on hatchability of eggs from Bronze turkey breeders of different ages M. Özçelik 1#, F. Ekmen 2 and Ö. Elmaz 1 1 Mehmet Akif Ersoy University, Faculty of
More informationEffective Hatching Egg Sanitization. Craig D. Coufal, Ph.D.
Effective Hatching Egg Sanitization Craig D. Coufal, Ph.D. Consequences A lack of hatching egg disinfection can lead to: Contaminated/exploding eggs Reduced hatch Cross contamination throughout the hatchery
More informationAn Evaluation of Interior Quality of Shell Eggs Packed in the Carton While Still Warm 1
LEO AND FOOT ABNORMALITIES 461 faulty bone formation. Animal Nutrition and Health, 22: 17-18. Nairn,M. E., 1969. Astudy of infectiousosteomyelitis and synovitis of turkeys. Ph.D. Thesis, University of
More informationEffect of Calcium Level of the Developing and Laying Ration on Hatchability of Eggs and on Viability and Growth Rate of Progeny of Young Pullets 1
1328 E. J. DAY AND B. C. DILWOETH for calcium:phosphorus ratios shows that toe ash was lowest for the birds receiving the rations containing the most narrow calcium:phosphorus ratio. Again, this observation
More informationEffects of breeder age on mineral contents and weight of yolk sac, embryo development, and hatchability in Pekin ducks
Effects of breeder age on mineral contents and weight of yolk sac, embryo development, and hatchability in Pekin ducks E. E. Onbaşılar,* 1 E. Erdem, Ö. Hacan, and S. Yalçın * Faculty of Veterinary Medicine,
More informationVariation of Chicken Embryo Development by Temperature Influence. Anna Morgan Miller. Rockdale Magnet School for Science and Technology
Variation of Chicken Embryo Development by Temperature Influence Anna Morgan Miller Rockdale Magnet School for Science and Technology Anna Morgan Miller Rockdale Magnet School 1174 Bulldog Circle Conyers,
More informationSpraying hatching eggs with electrolyzed oxidizing water reduces eggshell microbial load without compromising broiler production parameters
Spraying hatching eggs with electrolyzed oxidizing water reduces eggshell microbial load without compromising broiler production parameters G. M. Fasenko, 1 E. E. O Dea Christopher, and L. M. McMullen
More informationMAXIMIZING FERTILITY WITH ROOSTER MANAGEMENT. Jeanna L. Wilson University of Georgia
MAXIMIZING FERTILITY WITH ROOSTER MANAGEMENT Jeanna L. Wilson University of Georgia Some might ask why we are having issues with fertility? To answer that question let s take a look back 6 week old broilers,
More informationIncubation conditions affect leg health in large, high-yield broilers
2009 Poultry Science Association, Inc. Incubation conditions affect leg health in large, high-yield broilers E. O. Oviedo-Rondón, 1 M. J. Wineland, S. Funderburk, J. Small, H. Cutchin, and M. Mann Department
More information4-H Poultry: Unit 1. The Egg Flock For an egg-producing flock, select one of these birds: production-type Rhode Island Red Leghorn hybrids sex-link
4-H Poultry: Unit 1 A small flock of chickens does not require much space or money, and if you manage your flock well, you can earn some money. You might start with a small flock of 25 50 chickens, or
More informationSystematic factors that affect ostrich egg incubation traits
315 Systematic factors that affect ostrich egg incubation traits Z. Brand 1,2#, S.W.P. Cloete 1,3, C.R. Brown 4 and I.A. Malecki 5 1 Department of Animal Sciences, University of Stellenbosch, Private Bag
More informationAvian Reproductive System Female
extension Avian Reproductive System Female articles.extension.org/pages/65372/avian-reproductive-systemfemale Written by: Dr. Jacquie Jacob, University of Kentucky For anyone interested in raising chickens
More informationUnit E: Other Poultry. Lesson 2: Exploring the Duck Industry
Unit E: Other Poultry Lesson 2: Exploring the Duck Industry 1 1 2 I. There are many types of ducks throughout the world and in Afghanistan. A. Both domesticated and wild ducks exist throughout the world.
More informationEGG production of turkeys is not important
A Study of Egg Production in Bronze Turkeys S. J. MAESDEN National Agricultural Research Center, Beltsville, Maryland EGG production of turkeys is not important commercially but good egg production during
More informationINCUBATION TEMPERATURE
INCUBATION TEMPERATURE For most chicken species, the optimum incubation temperature lies between 37.0 and 38.0 o Cen. The optimal value being 37.8 o Cen (100.0 o F ) Embryos are more sensitive to high
More informationSmall Flock Series: Incubation of Poultry
1 of 13 1/7/2010 1:29 PM University of Missouri Extension G8353, Revised February 2003 Small Flock Series: Incubation of Poultry Jesse J. Lyons Department of Animal Sciences Hatching eggs watching an egg
More informationWe engineer your success. All over the world. HatchCare Automation. Improving animal welfare
We engineer your success. All over the world. HatchCare Automation Improving animal welfare HatchCare Automation Improving animal welfare a Live embryo transfer a In-ovo vaccination a Stress-free chick
More informationArkansas State FFA Poultry Exam 2016
Arkansas State FFA Poultry Exam 2016 Write answers on scantron. 1. For a typical egg laying operation, the production goals for a hen housed during a 52-80 week laying period is. a) 120 140 eggs b) 160-180
More information206 Adopted: 4 April 1984
OECD GUIDELINE FOR TESTING OF CHEMICALS 206 Adopted: 4 April 1984 1. I N T R O D U C T O R Y I N F O R M A T I O N P r e r e q u i s i t e s Water solubility Vapour pressure Avian dietary LC50 (See Test
More informationColorado Reader AG IN THE CLASSROOM HELPING THE NEXT GENERATION UNDERSTAND THEIR CONNECTION TO AGRICULTURE
Colorado Reader AG IN THE CLASSROOM HELPING THE NEXT GENERATION UNDERSTAND THEIR CONNECTION TO AGRICULTURE COLORADO FOUNDATION FOR AGRICULTURE ~ WWW.GROWINGYOURFUTURE.COM The Hen Eggs pert Producer Most
More informationON COMMERCIAL poultry farms during
Effect of Date of Hatch on Weight F. P. JEFFREY Department of Poultry Husbandry, Rutgers University, New Brunswick, New Jersey (Presented at annual meeting June, 1940; received for publication May 23,
More informationFemale Persistency Post-Peak - Managing Fertility and Production
May 2013 Female Persistency Post-Peak - Managing Fertility and Production Michael Longley, Global Technical Transfer Manager Summary Introduction Chick numbers are most often reduced during the period
More informationFemale Persistency Post-Peak - Managing Fertility and Production
Female Persistency Post-Peak - Managing Fertility and Production Michael Longley, Global Technical Transfer Manager May 2013 SUMMARY Introduction Chick numbers are most often reduced during the period
More informationINDIAN POULTRY INDUSTRY GLITCHES
INDIAN POULTRY INDUSTRY GLITCHES Shortcomings and IoT Solutions By Kishore Ravichandran EXECUTIVE SUMMARY Indian poultry industry is fragmented, with large number of small scale players contributing to
More informationHATCH-OUT ANALYSIS AND REPEATABILITY ESTIMATES OF COMMON HATCHABILITY PROBLEMS IN ISA-BROWN BREEDER STOCK
Agrosearch (2013) Volume 13(2):51-58 http://dx.doi.org/10.4314/agrosh.v13i2.6 HATCH-OUT ANALYSIS AND REPEATABILITY ESTIMATES OF COMMON HATCHABILITY PROBLEMS IN ISA-BROWN BREEDER STOCK *Fayeye T. R. and
More informationPoultry Skillathon 2016
Age Divisions: Junior (8-11) Intermediate (12-14) Senior (15-18) Exhibitors will participate in age-based Skillathons. This study guide includes all topics an exhibitor might be tested on. Youth will only
More informationPOULTRY PRODUCTION TECHNICIAN: BROILER HATCHING EGG
POULTRY PRODUCTION TECHNICIAN: BROILER HATCHING EGG COURSE OTH9930: POULTRY OPERATIONS AND CARE 33 Prerequisite: AGR3000: Agriculture Safety (Note: Students are required to complete the prerequisite course
More informationDIFFERENT BREEDS DEMAND DIFFERENT INCUBATION MEASURES
CONCERNING POULTRY One can be puzzled by noticing that, from the same batch, in the same incubator, some of the chicks hatch normally, while others die before breaking the shell. Reading the following
More informationEggology (Grades K-2)
Eggology (Grades K-2) Grade Level(s) K - 2 Estimated Time 90 minutes Purpose Students will identify how the basic needs of a growing chick are met during egg incubation. Activities include identifying
More informationInfluence of incubation management on pipping position, hatching ability and survival of ostrich chicks
South African Journal of Animal Science 2011, 41 (no. 3) Influence of incubation management on pipping, hatching ability and survival of ostrich chicks Z. Brand 1,2#, S.W.P. Cloete 2,3, I.A. Malecki 4
More informationRedacted for Privacy
AN ABSTRACT OF THE THESIS OF Janice Irene Fuquay for the degree of Master of Science in Poultry Science presented on August 1, 1979 Title: Reproductive performance of broiler breeders maintained in cages
More informationPerformance of Sudanese native Dwarf and Bare Neck Chicken raised under improved traditional production system
AGRICULTURE AND BIOLOGY JOURNAL OF NORTH AMERICA ISSN Print: 2151-7517, ISSN Online: 2151-7525, doi:10.5251/abjna.2011.2.5.860.866 2011, ScienceHuβ, http://www.scihub.org/abjna Performance of Sudanese
More informationThe effects of shank length on incubation results of Japanese quails (Coturnix coturnix japonica) eggs and hatched chick shank length
The effects of shank length on incubation results of Japanese quails (Coturnix coturnix japonica) eggs and hatched chick shank length B. YILMAZ DIKMEN* and A. IPEK Faculty of Agriculture, Animal Science
More informationPurpose and focus of the module: Poultry Definition Domestication Classification. Basic Anatomy & Physiology
Module: Poultry Production Code: AP21 Purpose and focus of the module: It aims at providing students with adequate knowledge and skills in poultry husbandry techniques and farm management. Skill Objectives
More informationEffects of transportation-induced jarring on ratite embryo development and hatching success
Effects of transportation-induced jarring on ratite embryo development and hatching success M A Potter and S M Bassett Ratite Research Centre Ecology Group Institute of Natural Resources Massey University
More informationAviagenBrief. Management Advice for Parent Stock Production with Minimal Antibiotic Use. October 2017
AviagenBrief October 2017 Management Advice for Parent Stock Production with Minimal Antibiotic Use Authors: Anne-Marie Neetson - Global Head of Animal Welfare, Dr. Dan Pearson - Director of Veterinary
More informationThe breeding of birds is one of the ancient
Pakistan J. Zool., vol. 45(5), pp. 1215-1220, 2013 Hatching Traits as Influenced by Different Body Weight Categories in Four Close-Bred Flocks of Japanese Quails (Coturnix coturnix japonica) Ahmed Sultan
More informationHatching Chicks in the Classroom
Hatching Chicks in the Classroom Table of contents Part 1: Preparing for Incubation Part 2: Egg Activity Part 3: During Incubation Part 4: Hatching Part 5: After Hatching Part 6: Chicks and Chickens Glossary
More informationA Guide to Commercial Poultry Production in Florida 1
A Guide to Commercial Poultry Production in Florida 1 Carrol Douglas 2 FACTORS IN PLANNING A POULTRY OPERATION Independent or Contract Production (1) Independent egg producers have the total responsibility
More informationPoultry 2010 Structure of the U.S. Poultry Industry, 2010
United States Department of Agriculture Animal and Plant Health Inspection Service Poultry 2010 Structure of the U.S. Poultry Industry, 2010 Veterinary Services National Animal Health Monitoring System
More informationSafe Egg Handling for Small Egg-Laying Flocks and Operations
UNIVERSITY OF ALASKA FAIRBANKS LPM-00344 UNIVERSITY OF ALASKA FAIRBANKS Safe Egg Handling for Small Egg-Laying Flocks and Operations The information in this publication will assist producers, intermediaries
More informationEffect of Flock Age and Postemergent Holding in the Hatcher on Broiler Live Performance and Further- Processing Yield
2005 oultry Science Association, Inc. Effect of Flock Age and ostemergent Holding in the Hatcher on Broiler Live erformance and Further- rocessing Yield N. S. Joseph and E. T. Moran, Jr. 1 Department of
More informationBeginning of Life. 4-H Embryology School Enrichment Program. Samantha Nagurny Extension Agent, 4-H Youth Development Fairfax County
Beginning of Life 4-H Embryology School Enrichment Program Samantha Nagurny Extension Agent, 4-H Youth Development Fairfax County What are we doing? What is 4-H? Youth Development Programming Youth 5-19
More information